Home > Viscosity Reducer
Safety Data Sheet
Issue Date: 12/04/2022 Print Date: 12/04/2022 Initial Date: 12/04/2022 V.0229.13.01
Product Identifier
|
Product name |
Viscosity Depressant |
|
Product model |
RT5-04 |
|
Synonyms |
|
|
Other means of identification |
Not Available |
Relevant identified uses of the substance or mixture and uses advised against
|
Relevant identified uses |
Reduction of Viscosity of Emulsified Crude Oil by Chemical Method. |
|
Uses advised against |
Industrial use only. |
Details of the supplier of the safety data sheet
|
Registered company name |
Tianjin RealTech International Co., Ltd |
|
Address |
Baoneng Building Suite B504, Hongqiao, Tianjin, China |
|
Telephone |
(86) 186 5376 7086 |
|
|
Emergency telephone number
|
Association/Organization |
Tianjin RealTech International Co., Ltd |
|
Emergency telephone numbers |
(86)156 8932 3262 |
Hazard classification according to GHS
|
Acute Toxicity – Oral |
Category 3 |
|
Acute Toxicity – Dermal |
Category 3 |
|
Acute Toxicity – Inhalation |
Category 3 |
|
Specific Target Organ Toxicity (Single Exposure) |
Category 1 |
Label elements
|
Hazard pictograms |
|
|
Signal Word |
Danger |
Hazard statement(s)
|
H301 |
Toxic if swallowed |
|
H311 |
Toxic in contact with skin |
|
H331 |
Toxic if inhaled |
|
H370 |
Causes damage to organs |
Precautionary statement(s)
|
Prevention |
P260 |
Do not breathe dust/fume/gas/mist/vapours/spray. |
|
P264 |
Wash thoroughly after handling. |
|
|
P270 |
Do not eat, drink or smoke when using this product. |
|
|
P271 |
Use only outdoors or in a well-ventilated area. |
|
|
P280 |
Wear protective gloves/protective clothing/eye protection/face protection. |
|
|
Response |
P312 |
Call a POISON CENTER/doctor, if you feel unwell. |
|
P330 |
Rinse mouth. |
|
|
P301+P310 |
IF SWALLOWED: Immediately call a POISON CENTER/doctor |
|
|
P302+P352 |
IF ON SKIN: Wash with plenty of water. |
|
|
P304+P340 |
IF INHALED: Remove person to fresh air and keep comfortable for breathing. |
|
|
P308+P311 |
IF exposed or concerned: Call a POISON CENTER/doctor. |
|
|
P361+P364 |
Take off immediately all contaminated clothing and wash it before reuse. |
|
|
Storage |
P405 |
Store locked up. |
|
P403+P233 |
Store in a well-ventilated place. Keep container tightly closed. |
|
|
Disposal |
P501 |
Dispose of contents/container in accordance with local / regional / national / international regulations. |
Hazard description- Physical and chemical hazards
|
Physical and chemical hazards |
No information available |
Hazard description- Health hazards
|
Inhaled |
Inhalation of vapors or aerosols (mists, fumes), generated by the product during normal handling, may produce toxic effects. |
|
Ingestion |
Toxic effects may result from the accidental ingestion of the product. |
|
Skin Contact |
Toxic in contact with skin, systemic effects may result following absorption. |
|
Eye |
This product may cause temporary discomfort following direct contact with the eye. |
Hazard description- Environmental hazards
|
|
Please refer to 12th chapter of SDS. |
SECTION 3 COMPOSITION / INFORMATION ON INGREDIENTS
|
Component |
Cas No. |
EC No. |
Concentration (weight percent, %) |
|
Polyoxyethylene polyoxyacrylate |
- |
- |
10-50 |
|
Polyethylene glycol nonylphenyl ether |
9016-45-9 |
- |
18-20 |
|
Methanol |
67-56-1 |
200-659-6 |
2-35 |
|
Water |
7732-18-5 |
231-791-2 |
20-25 |
SECTION 4 FIRST AID MEASURES
Description of first aid measures
|
General advice |
Immediate medical attention is required. Show this safety data sheet (SDS) to the doctor in attendance. |
|
Eye contact |
Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician if feel uncomfortable. |
|
Skin contact |
Take off contaminated clothing and shoes immediately. Wash off with plenty of water for at least 15 minutes and consult a physician if feel uncomfortable. |
|
Ingestion |
Do not induce vomiting. Never give anything by mouth to an unconscious person. Call a physician or Poison Control Center immediately. |
|
Inhalation |
Move victim into fresh air. If breathing is difficult, give oxygen. Do not use mouth to mouth resuscitation if victim ingested or inhaled the substance. If not breathing, give artificial respiration and consult a physician immediately. |
|
Protecting of first-aiders |
Ensure that medical personnel are aware of the substance involved. Take precautions to protect themselves and prevent spread of contamination. |
Most important symptoms and effects, both acute and delayed
|
1 |
Substance accumulation, in the human body, may occur and may cause some concern following repeated or long-term occupational exposure. |
Indication of any immediate medical attention and special treatment needed
|
1 |
Treat symptomatically. |
|
2 |
Symptoms may be delayed. |
Extinguishing media
|
Suitable extinguishing media |
Use extinguishing agent suitable for type of surrounding fire. |
|
Unsuitable extinguishing media |
No special notes. |
Advice for firefighters
|
1 |
As in any fire, wear self-contained breathing apparatus (MSHA/NIOSH approved or equivalent) and full protective gear. |
|
2 |
Fight fire from a safe distance, with adequate cover. |
|
3 |
Prevent fire extinguishing water from contaminating surface water or the ground water system. |
Personal precautions, protective equipment and emergency procedures
|
1 |
Ensure adequate ventilation. Remove all sources of ignition. Take precautionary measures against static discharges. |
|
2 |
Evacuate personnel to safe areas. Keep people away from and upwind of spill/leak. |
|
3 |
Use personal protective equipment. |
Environmental precautions
|
1 |
Prevent further leakage or spillage if safe to do so. |
|
2 |
Discharge into the environment must be avoided. |
Methods and materials for containment and cleaning up
|
1 |
Cover with wet earth, sand or other non-combustible material. |
|
2 |
Adhered or collected material should be promptly disposed of, in accordance with appropriate laws and regulations. |
|
3 |
Remove all sources of ignition. Use spark-proof tools and explosion-proof equipment. |
Precautions for safe handling
|
1 |
Handling is performed in a well-ventilated place. |
|
2 |
Wear suitable protective equipment. |
|
3 |
Avoid contact with skin and eyes. |
|
4 |
Keep away from heat/sparks/open flames/ hot surfaces. |
Precautions for storage
|
1 |
Keep containers tightly closed. |
|
2 |
Keep containers in a dry, cool and well-ventilated place. |
|
3 |
Keep away from heat/sparks/open flames/hot surfaces. |
|
4 |
Containers which are opened must be carefully resealed and kept upright to prevent leakage. |
Control parameters
|
Occupational Exposure limit values |
Component |
Country/Region |
Limit value - Eight hours |
Limit value - Short term |
||
|
ppm |
mg/m³ |
ppm |
mg/m³ |
|||
|
Methanol 67-56-1 |
USA - OSHA |
200 |
260 |
- |
- |
|
|
South Korea |
200 |
260 |
250 |
310 |
||
|
Ireland |
200 |
260 |
- |
- |
||
|
Germany (AGS) |
200 |
270 |
800 |
1080 |
||
|
Denmark |
200 |
260 |
400 |
520 |
||
|
Australia |
200 |
262 |
250 |
328 |
||
|
Biological limit values |
No information available |
|||||
|
Monitoring methods |
|
|||||
Engineering controls
|
1 |
Ensure adequate ventilation, especially in confined areas. |
|
2 |
Ensure that eyewash stations and safety showers are close to the workstation location. |
|
3 |
Use explosion-proof electrical/ventilating/lighting/equipment. |
|
4 |
Set up emergency exit and necessary risk-elimination area. |
Personal protection equipment
|
General requirement |
 |
 |
 |
 |
|
 |
|
Eye protection |
Tightly fitting safety goggles (approved by EN 166(EU) or NIOSH (US). |
|||||
|
Hand protection |
Wear protective gloves（such as butyl rubber）, passing the tests according to EN 374(EU), US F739 or AS/NZS 2161.1 standard. |
|||||
|
Respiratory protection |
If exposure limits are exceeded or if irritation or other symptoms are experienced, use a full-face respirator with multi-purpose combination (US) or type AXBEK (EN 14387) respirator cartridges. |
|||||
|
Skin and body protection |
Wear fire/flame resistant/retardant clothing and antistatic boots. |
|||||
 |
Information on basic physical and chemical properties
|
Appearance |
Colorless to yellowish liquid |
Odour |
No special odor |
|
Physical state |
Liquid |
Odour threshold |
No data available |
|
Relative density (Water =1) |
No data available |
Partition coefficient n- octanol / water |
No data available |
|
pH (as supplied) |
6~9 |
Auto-ignition temperature (°C) |
No data available |
|
Melting point/freezing point(℃) |
No data available |
Decomposition temperature |
No data available |
|
Initial boiling point and boiling range (°C) |
No data available |
Kinematic viscosity |
No data available |
|
Flash point (closed cup, °C) |
23-30 |
Molecular weight (g/mol) |
No data available |
|
Evaporation rate |
No data available |
Particle characteristics |
Not applicable |
|
Flammability |
No data available |
Explosive properties |
No data available |
|
Upper Explosive Limit (%) |
No data available |
Oxidising properties |
No data available |
|
Lower Explosive Limit (%) |
No data available |
Surface Tension (dyn/cm or mN/m) |
No data available |
|
Vapour pressure (kPa) |
No data available |
Volatile Component (%vol) |
No data available |
|
Solubility (g/L) |
No data available |
Gas group |
No data available |
|
Vapour density (Air = 1) |
No data available |
pH as a solution (1%) |
No data available |
|
VOC g/L |
No data available |
|
|
|
Reactivity |
Contact with incompatible substances may cause decomposition or other chemical reactions. |
|
Chemical stability |
Stable under proper operation and storage conditions. |
|
Possibility of hazardous reactions |
No information available |
|
Conditions to avoid |
Incompatible materials, heat, flame and spark. |
|
Incompatible materials |
No information available |
|
Hazardous decomposition products |
Under normal conditions of storage and use, hazardous decomposition products should not be produced. |
SECTION 11 TOXICOLOGICAL INFORMATION
Acute toxicity
|
Component |
Cas No. |
LD50(oral) |
LD50(dermal) |
LC50(inhalation,4h) |
|
Methanol |
67-56-1 |
5628mg/kg (Rat) |
15800mg/kg (Rabbi t) |
83.867mg/L(Rat) |
Carcinogenicity
|
Component |
Cas No. |
IARC |
NTP |
|
Polyoxyethylene polyoxyacrylate |
9003-11-6 |
Not Listed |
Not Listed |
|
Polyethylene glycol nonylphenyl ether |
9016-45-9 |
Not Listed |
Not Listed |
|
Methanol |
67-56-1 |
Not Listed |
Not Listed |
|
Water |
7732-18-5 |
Not Listed |
Not Listed |
Other
|
Skin corrosion/irritation |
No information available |
|
Serious eye damage/irritation |
No information available |
|
Skin sensitization |
No information available |
|
Respiratory sensitization |
No information available |
|
Reproductive toxicity |
No information available |
|
STOT-single exposure |
Causes damage to organs (Category 1) |
|
STOT-repeated exposure |
No information available |
|
Aspiration hazard |
No information available |
|
Germ cell mutagenicity |
No information available |
|
Reproductive toxicity(additional) |
No information available |
|
Acute aquatic toxicity |
Component |
Cas No. |
Fish |
Crustaceans |
Algae |
||||
|
Methanol |
67-56-1 |
LC50: 24000mg/L (96h)(Fish) |
EC50: 24500mg/L (48h) (Crustaceans) |
No information available |
|||||
|
Chronic aquatic toxicity |
No data available |
||||||||
|
Persistence and degradability |
Component |
Cas No. |
Persistence (water/soil) |
Persistence (air) |
|||||
|
Methanol |
67-56-1 |
Low |
Low |
||||||
|
Water |
7732-18-5 |
Low |
Low |
||||||
|
Bioaccumulative potential |
Component |
Cas No. |
Bioaccumulative potential |
Comments |
|||||
|
Methanol |
67-56-1 |
Low |
BCF=10 |
||||||
|
|
Water |
7732-18-5 |
Low |
LogKOW=-1.38 |
|||||
|
Mobility in soil |
Component |
Cas No. |
Mobility in soil |
Comments |
|||||
|
Methanol |
67-56-1 |
High |
1 |
||||||
|
Water |
7732-18-5 |
Low |
14.3 |
||||||
|
Results of PBT and vPvB assessment |
Component |
Cas No. |
Results of PBT and vPvB assessment |
||||||
|
Methanol |
67-56-1 |
not PBT/vPvB |
|||||||
|
Water |
7732-18-5 |
not PBT/vPvB |
|||||||
|
Other information |
No data available |
||||||||
|
Waste chemicals |
Before disposal should refer to the relevant national and local laws and regulation. |
|
Contaminated packaging |
Containers may still present chemical hazard when empty. Keep away from hot and ignition source of fire. |
|
Disposal recommendations |
Refer to section 13.1and 13.2. |
|
Transporting Label |
|
|
|
Marine pollutant |
None |
|
|
Land transport (UN-ADR) |
UN number |
1993 |
|
UN proper shipping name |
FLAMMABLE LIQUID, N.O.S. |
|
|
Transport hazard class |
3 |
|
|
Transport subsidiary hazard class |
None |
|
|
Packing group |
Ⅲ |
|
|
Special provisions |
274|601|640E |
|
|
Limited quantities |
5 L |
|
|
Excepted quantities |
E1 |
|
|
Packing instructions |
P001|IBC03|LP01|R001 |
|
|
Special packing provisions |
- |
|
|
Mixed packing provisions |
MP19 |
|
|
Portable tanks and bulk containers instructions |
T4 |
|
|
Portable tanks and bulk containers special provisions |
TP1|TP29 |
|
|
ADR tank code |
LGBF |
|
|
ADR tank special provisions |
- |
|
|
Vehicle for tank carriage |
FL |
|
|
Transport category (Tunnel restriction code) |
3 (D/E) |
|
|
Special provisions for carriage (Packages) |
V12 |
|
|
Special provisions for carriage (Bulk) |
- |
|
|
Special provisions for carriage (Loading, unloading and handling) |
- |
|
|
Special provisions for carriage (Operation) |
S2 |
|
|
Hazard identification No. |
30 |
|
|
Notes |
- |
|
|
Air transport (ICAO-IATA/DGR) |
UN number |
1993 |
|
UN proper shipping name |
FLAMMABLE LIQUID, N.O.S. |
|
|
Transport hazard class |
3 |
|
|
Transport subsidiary hazard class |
None |
|
|
Packing group |
Ⅲ |
|
|
Excepted quantities |
E1 |
|
|
Passenger and Cargo Aircraft Limited Quantity Packing Instructions |
Y344 |
|
|
Passenger and Cargo Aircraft Limited Quantity Maximum Net Quantity per Package |
10L |
|
|
Passenger and Cargo Aircraft Packing Instructions |
355 |
|
|
Passenger and Cargo Aircraft Maximum Net Quantity per Package |
60L |
|
|
Cargo Aircraft Packing Instructions |
366 |
|
|
Cargo Aircraft Maximum Net Quantity per Package |
220L |
|
|
Special provisions |
A3 |
|
|
ERG code |
3L |
|
|
Sea transport (IMDG-Code/GVSee) |
UN number |
1993 |
|
UN proper shipping name |
FLAMMABLE LIQUID, N.O.S. |
|
|
Transport hazard class |
3 |
|
|
Transport subsidiary hazard class |
None |
|
|
Packing group |
Ⅲ |
|
|
Special provisions |
223 274 955 |
|
|
Limited quantities |
5L |
|
|
Excepted quantities |
E1 |
|
|
Marine pollutant (Yes or no) |
No |
|
|
EmS No. |
F-E, S-E |
|
International chemical inventory
|
Component |
EINECS |
TSCA |
DSL |
IECSC |
NZIoC |
PICCS |
KECI |
AICS |
ENCS |
|
Polyoxyethylene polyoxyacrylate |
× |
× |
× |
× |
× |
× |
× |
× |
× |
|
Polyethylene glycol nonylphenyl ether |
√ |
√ |
√ |
√ |
√ |
√ |
√ |
√ |
× |
|
Methanol |
√ |
√ |
√ |
√ |
√ |
√ |
√ |
√ |
√ |
|
Water |
√ |
√ |
√ |
√ |
√ |
√ |
√ |
√ |
× |
【EINECS】 European Inventory of Existing Commercial Chemical Substances
【TSCA】 United States Toxic Substances Control Act Inventory
【DSL】 Canadian Domestic Substances List
【IECSC】 China Inventory of Existing Chemical Substances
【NZIoC】 New Zealand Inventory of Chemicals
【PICCS】 Philippines Inventory of Chemicals and Chemical Substances
【KECI】Existing and Evaluated Chemical Substances
【AICS】Australia Inventory of Chemical Substances
【ENCS】Existing And New Chemical Substances
Note
“√” Indicates that the substance included in the regulations “×” That no data or included in the regulations
REVISED INFORMATION: Significant changes to regulatory or health information for this revision is indicated by a bar in the left-hand margin of the SDS.
Reference
[1]IPCS:The International Chemical Safety Cards (ICSC) ,website: http://www.ilo.org/dyn/icsc/showcard.home.
[2]IARC，website: http://www.iarc.fr/.
[3]OECD: The Global Portal to Information on Chemical Substances, website:
http://www.echemportal.org/echemportal/index?pageID=0&request_locale=en.
[4]CAMEO Chemicals, website: http://cameochemicals.noaa.gov/search/simple.
[5]NLM:ChemIDplus, website: http://chem.sis.nlm.nih.gov/chemidplus/chemidlite.jsp.
[6]EPA: Integrated Risk Information System, website: http://cfpub.epa.gov/iris/.
[7]U.S. Department of Transportation:ERG, website: http://www.phmsa.dot.gov/hazmat/library/erg.
[8]Germany GESTIS-database on hazard substance, website: http://gestis-en.itrust.de/.
Abbreviations and acronyms
|
CAS –Chemical Abstracts Service |
CMR - Carcinogens, mutagens or substances toxic to reproduction |
|
PC-STEL- Short term exposure limit |
PC-TWA - Time Weighted Average |
|
DNEL - Derived No Effect Level |
IARC - International Agency for Research on Cancer |
|
RPE - Respiratory Protective Equipment |
PNEC –Predicted No Effect Concentration |
|
LC50 - Lethal Concentration 50% |
LD50 - Lethal Dose 50% |
|
NOEC -No Observed Effect Concentration |
EC50 - Effective Concentration 50% |
|
PBT - Persistent, Bioaccumulative, Toxic |
POW - Partition coefficient Octanol:Water |
|
BCF - Bioconcentration factor (BCF) |
vPvB - very Persistent, very Bioaccumulative |
|
IMDG-International Maritime Dangerous Goods |
ICAO/IATA-International Civil Aviation Organization/International Air Transportation Association |
|
UN-The United Nations |
ACGIH-American Conference of Governmental Industrial Hygienists |
|
NFPA-National Fire Protection Association |
OECD-Organization for Economic Co-operation and Development |
Disclaimer：
|
End of SDS |
